Kewaunee County dairy CAFO sues DNR over permit barring future expansion

Danielle Kaeding
Wisconsin Public Radio
Cows enjoy the comfort of the Kinnard family's new state-of-the-art cross-ventilated barn. The large Kewanee County dairy is using the Wisconsin DNR, saying the agency's decision to issue a modified permit was unlawful and should be reversed, changed or sent back for further review. Kinnard Farms said that the new limit was "unreasonably low" and affects the operation’s ability to remain competitive.

A controversial dairy farm in Kewaunee County is suing state environmental regulators over changes to its wastewater permit that strengthen groundwater monitoring and prevent the operation from expanding beyond its current size.

The Wisconsin Department of Natural Resources issued the modified permit to Kinnard Farms in Casco on March 25. The changes are tied to a Wisconsin Supreme Court decision last year that found regulators can require operating conditions on so-called factory farms known as concentrated animal feeding operations or CAFOs.

The DNR had initially included a proposal by Kinnard Farms that set a maximum limit of 21,450 animal units, or roughly the equivalent of 15,000 cows, as part of changes to its wastewater permit. Under the revised permit, the farm can’t have beyond 11,369 animal units or its current size of roughly 8,000 cows.

In the complaint filed Friday in Kewaunee County Circuit Court, the farm said the agency's decision to issue the permit was unlawful and should be reversed, changed or sent back for further review. Kinnard Farms said that limit was "unreasonably low" and affects the operation’s ability to remain competitive. 

"If Kinnard is restricted from increasing its herd size, Kinnard may lose revenue associated with the sale of milk from additional dairy cows," the complaint states. "Moreover, because fluctuations in herd size are a normal and expected consequence of dairy farming, the animal unit maximum will limit Kinnard’s operational flexibility and cause it to incur higher costs."

The farm’s attorney Jordan Hemaidan said it’s his policy not to comment on litigation and referred questions to Kinnard Farms. Kinnard Farms did not immediately respond to a request for comment on Tuesday.

However, Lee Kinnard, President of Kinnard Farms released a statement to the Wisconsin State Farmer saying "The Kinnard Farms family remains committed to regenerative agriculture and sustainability. On-farm practices such as planting cover crops, limited soil tillage (known as no-till), sand and water recycling and more demonstrate our dedication to protecting groundwater in our community. We continue to invest in cutting-edge innovation to protect our environment."

The permit issued by the DNR requires the farm to monitor two fields where manure is spread that are south and west of the farm with three wells on each field. The permit also requires hourly water level and temperature monitoring for at least one well.

In its complaint, Kinnard Farms said the changes threaten to cost the farm "tens of thousands of dollars" to design, install and maintain a groundwater monitoring system on those fields without adequate justification. The farm has also petitioned the DNR for a contested case hearing. Kinnard Farms contends that groundwater monitoring at the two sites won’t produce reliable data to ensure the farm is complying with its permit and groundwater standards.

Kinnard Farms argues it has enough storage and land to handle waste if the operation were to double in size.

Even without future expansion, a DNR fact sheet states groundwater monitoring data at Kinnard Farms has found "persistent exceedances of groundwater quality standards for nitrate and bacteria." Sampling of monitoring wells in production areas have shown nitrate concentrations of more than 20 milligrams per liter — double the state’s health and groundwater standards of 10 milligrams per liter.

Nitrates are the state’s most widespread contaminant and have been associated with birth defects, thyroid disease and colon cancer. Research has shown around 10 percent of the state’s 800,000 private wells exceed federal health standards for nitrates. Around 90 percent of nitrogen in groundwater can be traced back to agriculture.

Residents in Kewaunee County have struggled with drinking water contamination of private wells from agriculture for years. The region is susceptible to pollution from manure runoff due to thin soils and fractured bedrock that allow contamination to seep into groundwater more easily.

Clean Wisconsin Staff Attorney Evan Feinauer disputed in a statement that the farm could double its size without harming drinking water.

"There is no doubt Kewaunee families are facing serious water contamination issues and have been for years," said Feinauer. "This is about using science to understand what’s happening to our water resources and guide us to effective solutions that protect public health. Groundwater monitoring can help us identify potential problems that lead to contamination and also validate whether the important conservation efforts that are already underway are making an impact."

In July, the Wisconsin Supreme Court ruled the DNR had authority to impose permit conditions on Kinnard Farms to protect water quality as part of a case that challenged a permit issued by the DNR. The decision stemmed from a 2012 request by the farm to add a second site and more than 3,000 dairy cows, almost doubling the size of its operation at the time. Nearby residents challenged the permit, setting off years of litigation.

The Wisconsin Supreme Court ruling upheld a 2014 decision by an administrative law judge that ordered the DNR to require a limit on animals for Kinnard Farms in addition to offsite groundwater monitoring, citing "a crisis with respect to groundwater quality in the area."

Since then, the DNR reissued the farm's water quality permit in 2018, which was also challenged by residents. The agency reached a settlement with the farm that required changes to the permit if the state Supreme Court affirmed the DNR’s authority to require a cap and offsite monitoring.

The modified permit expires Jan. 31 of next year.

This article republished with permission from Wisconsin Public Radio